Make Homemade Bacon Using The Dry Rub Cure & Cold Smoke Method


Everybody loves bacon! So how great it would be to make this amazing treat at home, any time you feel like eating some of this amazing meat. You can make your own bacon at home in lots of different ways, but the easiest is to use a dry rub cure and learn the cold smoke technique. The secret to a great bacon is to smoke it just the right amount, so you get a tasty but light meat. Once you managed to smoke the bacon, leave it to rest for a few days, so all those delicious flavors can slowly develop. In the following, you can learn more about how to make the most delicious bacon at home. After that you can search for breakfast reciped involving bacon and invite your friends over for a tasty brunch!

2 lb – 7.5 oz
11 lb – 9.1 oz lb pork bellies. I buy them with the skin already removed: bacon-cold-smoke


You will need kosher salt, sugar and cure #1 A.K.A. prague powder, instacure or pink salt.
Its easiest to work in grams and I just found the 2nd of the two calculators below and its much simpler and cleaner than the first one plus it has a conversion calculator as well.
Dry Cure Bacon Calculator
Better Dry Cure Bacon Calculator

I have found that for me 2.5% salt and 1.5% sugar is about perfect.
I also stay between 156-160 PPM Sodium Nitrite (the USDA says it must be between 120 ppm & 200 ppm for dry cure skin off bacon).




Combine the ingredients and mix well. A large canning jar with tight fitting lid works well. Shake the ingredients until the pink color of the Cure 1 is evenly distributed throughout the cure mix.

Measured and mixed cures, I marked it with a sharpie to divide the cure into thirds and marked the slab weight so I could keep them with the proper slabs:

bacon-cold-smoke-2 Rub about 1/3 of the mix evenly/predominantly on the meat side(s) of the bellies.



Loosely wrap in plastic wrap and lay flat in a carboy tray or other plastic tray with the meat side up and refrigerate at 38º to 40º:


Wait 3 – 4 days and repeat applying the 2nd 1/3 of the cure to the meat side only. Do not dry the bacon at this point just drain any liquid trapped in the plastic wrap and on the bottom of the lug.
Let the curing bacon sit another 3 – 4 more days and repeat adding the balance of the cure mix to the meat side. You may also add any extra salt, sugar or spices at this stage. 3-4 days later rinse the bacon with fresh water and pat dry with a clean towel.

At this point you may want to do a taste test for salt by frying a small piece. If too salty, soak in fresh water for an hour and repeat taste test. You can repeat the process until the salt in the bacon is where you want it but this recipe and procedure seldom produces bacon most would consider too salty. I don’t bother to do the fry test anymore at these percentages.

Now you just need to determine when you have access and time to do your cold smoking. I have left the bacon in the refrigerator mellowing out for up to 3 additional days after rinsing, but the bacon is now fully cured and ready for the smoker.

Make sure the bacon is dry by hanging in front of a fan or in the smoker with a low heat but no smoke. There are Bacon Hangers commercially available or you can just put them on the racks but I find I get a more evenly smpked product and no marks by hanging the slabs.

You want to develop a pellicle that will hold the smoke on the bacon. The bacon should be dry but slightly tacky to the touch when properly dried.




Cold Smoking: I have gone as little as 8 hours and as long as 36 hours with cold smoking. I usually burn 3 or 4 A-MAZE-N-PELLET-SMOKERS (AMNPS) full of pellets (I like a blend of Hickory & Apple), I suggest you smoke the bacon until you get the color you like & the smokiness you are after. I like a nice mahogany color and more smoke than what you find in commercial bacon’s.
Remember to try keep your smoker below 100 degrees. Fat starts to render out somewhere around that temperature. I have had my chamber temps get as high as 135º and still had delicious bacon. Ideally I like to keep my chamber temperature between 35º and 80º but its not always possible if its real hot out unless you add trays of ice above your smoke source.

It was 0º the morning I put this these in the smoker, I lit two AMNPS just to keep my chamber temp above freezing.


3 AMNPS and 20 hours later: bacon-cold-smoke-10

Let the newly smoked bacon rest in the fridge for several days to mellow and let the smoke distribute itself evenly and the flavors develop. Then slice and package your bacon:


bacon-cold-smoke-12 bacon-cold-smoke-13




It can be kept in the fridge for several weeks in this stage or frozen.

A few slices didn’t make the vacuum sealer



by FrozenTundra

Filed in: Food & Recipes Tags: , ,

You might like:

Couple Build Amazing Shipping Container Home For Debt-Free Living
You Can Plant Midnight Oil Blue Sunflowers
Teen and his cow lose at state fair, take a nap together and win hearts of millions instead
250 Starving Lions Found In Raid On Trophy Hunting Farm

Leave a Reply

Submit Comment

© Homestead Ideas. All rights reserved. XHTML / CSS Valid.